MD-11 Checklist & Procedures Quickview v0.1.pdf

MD-11 Checklist & Procedures Quickview v0.1.pdf

1. TFDi Design MD-11
Checklist & Procedures for MS Flight Simulator
by PH-BKO (v0.1)

NOTES
This checklist / procedure list is for
flight simulator use only . This document
is based on the TFDi Design MD-11 MSFS
manual/checklist.

Bold items should be followed. Items that
are not bold, could be skipped “safely” ,
but add to the immersion if followed .

PANEL ABBREVIATIONS
OH Overhead
FMS Flight Management System
EIS Electronic Instrument System
FCP Flight Control Panel
PFD Primary Flight Display
MP Main Panel
ND Navigation Display
EAD Engine and Alert Display
SD Systems Display
SDCP Systems Display Control Panel
FMA Flight Mode Annunciator
CP Center Panel
MCDU Multi-Functional Control Display
Unit
PD Pedestal
CC Center Console


SPECIFICATIONS / LIMITATIONS
PAX FREIGHT
Max. Takeoff Weight
(lbs)
618.000
Max. Landing Weight
(lbs)
440.000
Service Ceiling (ft) 43.000
Normal Range (30 min.
reserve) (nm)
6.725 3.533
Fuel Capacity (lbs) 258.721
Takeoff Distance (ft) 9.725


SPEEDS
Max. Slats 280 KTS
Max. Flaps 1-15 255 KTS
Max. Flaps 16-20 240 KTS
Max. Flaps 21-25 220 KTS
Max. Flaps 28 210 KTS
Max. Flaps 35 190 KTS
Max. Flaps 50 175 KTS
Max. Gear Extension 260 KTS
Max. Gear Retraction 230 KTS
Max. Crosswind 35 KTS
Max. Tailwind 10 KTS


COCKPIT ENTRY
Weather Radar (CC) OFF
Fuel Switches (PD) OFF
Parking Brake (PD) SET / CHOCKS
Spoiler Handle (PD) DOWN
Flap/Slats Handle (PD) UP + RETRACTED
Gear Handle (CP) DOWN
Fuel Dump Switches COVERED + OFF
Manif. Drain Switches COVERED + OFF
Emergency Power
Selector
OFF


PREFLIGHT
Battery Switch (OH) ON
Ext. Power Switches (OH) AS REQUIRED
Engine/APU Fire TEST
(OH)
PERFORM
- All 3 fire handles illuminate
- APU fire handle illuminates
- All 3 Engine Fuel Shutoff
Switches illuminate
- Both Master Warnings
illuminate
- Fire Bell sounds
- Level 3 alert messages appear
on EAD
Master Warning (EIS) PRESS
- Master Warnings extinguish
- Fire Bell silences
Fuel Used (OH) RESET
Annunciator Lights (OH) TEST/CHECK
Annun Brt/Dim switch
(OH)
SELECT
Cargo Fire (OH) MANUAL TEST
- FWD/AFT Heat/Smoke lights
illuminates
- Manual Test switch illuminates
- All agent discharge lights
illuminate
- FWD/AFT Flow Switch DISAG
lights illuminate
- Both Master Warnings
illuminate
- Verify CRG FIRE LWR FWD + CRG
FIRE LWR AFT on EAD
IRS (OH) NAV
IRS (MCDU) INITIALIZE
Cockpit Voice Recorder
(OH)
TEST
Galley Bus panel (OH) ALL LIGHTS
EXTINGUISHED
Cargo Temp Selectors
(OH)
AS REQUIRED
FADEC/Engine Ign. Panel
(OH)
ALL LIGHTS
OUT EXCEPT
ENG IGN OFF

2. TFDi Design MD-11
Checklist & Procedures for MS Flight Simulator
by PH-BKO (v0.1)

Hydraulic Test (OH) PERFORM
Takes 1 minute, observe on SD
Electrical Panel (OH) CHECK
Manual light extinguished
Smoke Elec/Air Source
(OH)
NORMAL
Drive 1/2/3 + CAB BUS
(OH)
GUARDED
Emergency Power Selector
(OH)
ARMED, NO
LIGHT
Air Panel (OH) VERIFY
- Manual light extinguished
- ECON light extinguished
- TRIM AIR OFF light
extinguished
Cabin Outflow Valve (OH) OPEN
Air Conditioning (OH) ESTABLISH
Temp Selectors (OH) AS REQUIRED
Fuel Panel (OH) CHECK MAN.
LIGHT OUT
Fuel Quantity (OH) TEST
Observe 188880 displayed, then
10500 in each tank
Emergency Light Switch
(OH)
ARM
No Smoking Switch (OH) ON
Seat Belt Switch (OH) OFF
Exterior Lights (OH) AS REQUIRED
EVAC Panel (OH) ARMED +
GUARDED
GPWS Test Switch (OH) TEST +
GUARDED
AFS Panel (OH) CHECK
- All lights extinguished
- Flap limit NORMAL
- Elevator Feel NORMAL
Cabin Pressurization
Panel (OH)
CHECK
- AUTO
- Valve open
- Ditching switch guarded and
light extinguished
Anti-Ice Panel (OH) CHECK
Check all lights extinguished
Windshield Anti-Ice /
Defog (OH)
NORM/ON/DEFOG
LT OUT
Altimeter (EIS) SET LOCAL QNH
IAS (FCP) AUTO
HDG (FCP) AUTO
FEET (FCP) AUTO
Bank Selector (FCP) AUTO
Static Air Switch (MP) NORMAL
Source Input Selectors
(MP)



LIGHTS OUT
PFD/ND/EAD/SD (MP) CHECK
- No faults
- Baro / altimeters as desired
- Time correct
- Oil quantity ≥ 16 quarts
- PFD FMA annunciator TAKEOFF
Gear Handle (CP) DOWN + 4
GREEN
Auto Brake Switch (PD) RTO
Overboost Breakout bar
(PD)
FULL AFT
Throttles (PD) CHECK
- Check travel and aural
warnings
- 1 forward = Spoilers or Brakes
- 2+3 forward = Spoilers or
Brakes
Throttles (PD) CLOSED
Reverse Levers (PD) DOWN
Dial-a-Flap (PD) TO SETTING
Engine Start Buttons
(PD)
PRESSED IN

Fuel Switches (PD) OFF
SDCP (CC) CUE LIGHTS +
CLEAR
Radio Panels (CC) AS DESIRED
Weather Radar (CC) TEST + OFF
Transponder (CC) SET
Rudder Trim (CC) ZERO
Aileron Trim (CC) ZERO
Air Driven Generator
(CC)
HANDLE DOWN +
WIRED


BEFORE START
APU (OH) START
FMS (MCDU) INITIALIZED +
CHECKED
- Confirm weights
- Confirm head/tailwind
- Confirm runway slope
- Confirm temperature
- Confirm V-speeds
IRS (OH/MCDU) NAV + ALIGNED
EIS/BUGS (EIS/FCP) SET
Seat Belt Sign (OH) ON
Ext. Power Switches OFF
AUX HYD Pump 1 (CC) ON
Engine Ignition (OH) A OR B
Beacon Light (OH) ON

3. TFDi Design MD-11
Checklist & Procedures for MS Flight Simulator
by PH-BKO (v0.1)

ENGINE START
Engine #3 Start
Switch (PD)
PULL
Fuel Lever (PD) ON
At N2 ≥ 15%
Oil Pressure (SD) VERIFY RISE
Engine Ignite VERIFY ≤ 25 SEC
EGT (EAD) CHECK
Start Valve VERIFY CLOSES AT
45% N2
Engine #3 (EAD/SD) VERIFY STABILIZED
- N1 ± 20%
- EGT ± 400C
- N2 ± 60
- Oil ± 2 quarts after start
- Fuel Flow ± 1200 at Sea Level
Engine Anti-Ice (OH) AS REQUIRED
On if ≤10C and visible moisture

REPEAT FOR ENGINE 1, THEN 2


AFTER START
Engine Anti-Ice (OH) AS REQUIRED
APU (OH) OFF
Flaps (PD) SET
Config Page (SDCP) SELECT
Flight Controls CHECK
Stab Trim (PD) SET
From FMS T/O page, set on CONFIG
Taxi Lights (OH) ON


BEFORE TAKEOFF
EIS/BUGS (EIS/FCP) VERIFY
Runway (PFD) VERIFY
Anti-Ice (OH) WING OFF,
ENGINE AS REQ
Stab Trim (PD) VERIFY GREEN
BAND + CONFIG
Spoilers (PD) ARMED
Autobrake (CC) RTO
Flaps and Slats (PD) SET FOR TAKEOFF
Takeoff Data and Bugs VERIFY
EAD CHECKED
Landing Lights (OH) ON
HI INT (Strobes) (OH) ON
Flight Modes (FCP) AS REQUIRED
(ARM NAV, PROF,
AUTOFLIGHT)
- Arm NAV
- Arm PROF
- AUTOFLIGHT
- Verify TOGA power




AFTER TAKEOFF
Gear (CP) UP
Spoilers (PD) DISARM
Auto Brake (CC) VERIFY
Flaps/Slats (PD) UP/RETRACTED
EAD CHECK NO ALERTS


PASSING 10K
Sterile Cockpit (OH) CHIME
Landing Lights (OH) OFF


PASSING TRANSITION ALTITUDE
Altimeters (FCP) STD (PULL)
Dial-a-Flap (PD) SET 15


CRUISE
FMA VERIFY
- Pink = FMS controlling SPD,
ROLL, PITCH
- White = FCP values
- Green = Autoland annunciations
for LOC, GS, DUAL LND
FMS (MCDU) SETUP FOR DESCENT


CLEARED BELOW/PASSING TRANSITION LEVEL
Altimeters (FCP) LOCAL QNH


PASSING 10K
Landing Lights (OH) ON
Sterile Cockpit (OH) CHIME
Autobrakes (CC) AS REQUIRED


BEFORE LANDING
Gear (CP) DOWN
Flaps/Slats (PD) AS REQUIRED
Spoilers (PD) ARMED
Missed Approach
Altitude (FCP)
SET


AFTER LANDING
Reversers (PD) STOWED
Landing Lights (OH) OFF
HI INT (OH) OFF
Flaps/Slats (PD) UP/RETRACTED
Spoilers (PD) DOWN
Stabilizer Trim (PD) SET 3 DEG. UP
Weather Radar (CC) OFF
APU (OH) START

4. TFDi Design MD-11
Checklist & Procedures for MS Flight Simulator
by PH-BKO (v0.1)

PARKING
Parking Brakes (PD) SET
Fuel Switches (PD) OFF
Seat Belt Sign (OH) OFF
External Power (EFB/OH) AS REQUIRED
APU (OH) AS REQUIRED
Anti Ice (OH) OFF
Engine Ignition (OH) OFF
Exterior Lights (OH) ALL OFF,
EXCEPT NAV


SHUTDOWN
EMER LT Switch (OH) OFF
Emergency Power Switch (OH ) OFF
WSHLD Anti-ice and Defog (OH) OFF
IRS (OH) OFF
Cargo Temps (OH) OFF
Cockpit Lights (OH) OFF
EVAC Control Switch (OH) OFF
Packs (OH) OFF
APU (OH) OFF
Battery (OH) OFF